Volvo 240
Total questions 900
Where do you find a diagram for the air conditioning unit in a 1980 Volvo 242?
Get a copy of "Haynes Motor Repair Manual"---for your model they"re really good. The books are published in England but are...
Popularity: 80 • Tools: Recategorize
Where would the fuel pump relay be located on a 1986 Volvo 240 DL?
I may be way off, but in my '85 240, the relay is beneath the dash on the passenger side. I don't know if it was moved after 85....
Popularity: 64 • Tools: Recategorize
Where is the recharge port ac volvo 240 dl?
the valve is usually located on the back of the AC compressor itself. If not there, you could also look for it along the line by...
Popularity: 64 • Tools: Recategorize
What is the firing order for a 1982 Volvo 240 DL?
The firing order is 1 3 4 2 for the 4 cylinder engine
Popularity: 63 • Tools: Recategorize
If your 1990 Volvo 240 Series will not go into overdrive what can be wrong?
Check the overdrive relay switch. Answer Check O/D switch by all means....but the most common problem is usually the...
Popularity: 57 • Tools: Recategorize
How do you replace the voltage regulator in a 1988 240 Volvo?
The regulator is internal to the alternator! Just replace the alt. The alternator has an internal regulator that can be...
Popularity: 55 • Tools: Recategorize
How do you replace the alternator on a 1980 Volvo 240 GL?
Disconnect battery....... then the screw on terminal goes to battery( thick red wire)........ the green or white goes to...
Popularity: 55 • Tools: Recategorize
How do you remove the gear shift head on a 1991 Volvo 240 with an automatic transmission?
VERY CAREFULLY.
Popularity: 53 • Tools: Recategorize
Where is the fuel filter located on a 1989 Volvo 240?
It has two. The first is in the fuel tank, look under trunk mat for cover. Then to remove the filter you must knock the spin lock...
Popularity: 52 • Tools: Recategorize
What could be keeping a 1990 Volvo 240 series from going into overdrive?
Overdrive relay switch behind the middle air vents..... Answer Manual Transmission: the wires sometimes break if it is the...
Popularity: 52 • Tools: Recategorize
Where is the fuel filter located on a 1988 volvo 240 DL wagon?
It is located with the fuel pump under the drivers side of the car. It rests on a plate that also has the fuel pump attached to...
Popularity: 50 • Tools: Recategorize
What is the firing order for a 1988 Volvo 240?
1 3 4 2 with number 1 cylinder being at the radiator end of the engine Timbo's Answer...
Popularity: 46 • Tools: Recategorize
Where is the starter relay located on a 1986 Volvo 240dl?
I believe there isn't one.
Popularity: 45 • Tools: Recategorize
Where can you find the low pressure valve on a 1989 Volvo 240dl so you can add freon?
check the back of the compressor, they hide the there on the older models. volvodoctor
Popularity: 45 • Tools: Recategorize
Is a 1988 Volvo 240 DL know for bad power steering and if not how can you make your power steering better?
My Daughter has a 1988 240DL and the only time we have had problems with the power steering (P/S) is when the belt has broken. ...
Popularity: 45 • Tools: Recategorize
How do you change the brake pads on a 1987 Volvo 240DL?
Put the car on jack stands and remove the wheels. Locate the calipers and brake pads and remove the pins and clips from the...
Popularity: 45 • Tools: Recategorize
What are the steps to replace front brakes on a 1989 Volvo 240 DL?
Put the car on jack stands and remove the wheels. Locate the calipers and brake pads and remove the pins and clips from the...
Popularity: 45 • Tools: Recategorize
Are the headrests on your 1988 Volvo 245 removable?
If you will carefully press in on the backside of the material of the front seat back following a straight line downward from the...
Popularity: 45 • Tools: Recategorize
What is thel evel of difficulty in replacing a 1984 240DL fuel injector pump?
It depends on your experience with auto repair. The fuel pump itself is about a 2 and the pump inside the tank is about a 3.
Popularity: 45 • Tools: Recategorize
Where on the 1980 240 series Volvo do you refill the power steering fluid?
On the pump or into the little plastic bottle on the left hand side of engine bay (viewed from driver's seat). use Dexron 2 or2D...
Popularity: 44 • Tools: Recategorize
Where can you get a Volvo 240GL 1980 wiring diagram you have the manual but the diagrams are not clear?
the best diagrams are in the Haynes Repair Manuals for volvo---it is a complicated wiring system, but the haynes books are good ,...
Popularity: 44 • Tools: Recategorize
Where is the relay on volvo240se?
Which relay? There are at least 10 of them.
Popularity: 44 • Tools: Recategorize
What is the torque and sequence for tightening the headbolts on a Volvo 240?
Check if you have early type or later type head bolts. Early types have plain shanks, later types have a waist cut in them half...
Popularity: 43 • Tools: Recategorize
What is the firing order for a 1986 Volvo 240 4 cylinder?
1-3-4-2 as per Haynes Repair Manual #97020 for Volvo 240 series 1976 thru 1993 section 2A-1.
Popularity: 42 • Tools: Recategorize
What can be causing your 89 Volvo 240 Dl to stall when you go over 40 mph?
While there could be a lot of causes to your problem, as a 240 driver myself, I will give you what I know... First off, your car...
Popularity: 42 • Tools: Recategorize
What is the first position of the firing sequence of an 1989 Volvo 240 DL?
No. 1 is first, then 3-4-2. #1 is at the front of car.
Popularity: 42 • Tools: Recategorize
Where is the headlight relay on a Volvo 240?
You did not say what year. On the 1989 Volvo 240 GL, the headlight relay is mounted on the drivers side front fender just back...
Popularity: 41 • Tools: Recategorize
How do you replace the alternator on a 1986 Volvo 240?
There is abolt on the bottom of the alternator that holds the alternator to the engine. There is another bolt and bracket on the...
Popularity: 41 • Tools: Recategorize
Where is the turn signal relay on a 1993 Volvo 240 and how do you replace it?
Its in the lower section of the dash. You know the little storage area right in front of the gear shift? Remove the part of the...
Popularity: 39 • Tools: Recategorize
You retrieved the following codes from your 1990 240 DL position 2 113- 221- and 231 can you help you decode these codes?
In my day people went to lieberrys.
Popularity: 39 • Tools: Recategorize
What does it mean when it's difficult to press on the brakes?
if it is hard to press on the brakes it usually indicates that you have a malfunctioning brake booster. Since brake boosters...
Popularity: 39 • Tools: Recategorize
If a 90 Volvo 240 has voltage to the wiper motor in all positions and a good ground why doesn't it work even after replacing it?
Was the motor replaced by a new or known good used one?
Popularity: 38 • Tools: Recategorize
Will the 6 panel tail lights fit and work on a 244 DL that came with 5 panel lights?
It could......you can make anything fit and work....... it all depends on how much time and skill and knowhow you haveand MOST...
Popularity: 37 • Tools: Recategorize
Where is the adjustment for the belt on the condenser motor in the 1984 Volvo 240 DL and must the assisted steering be dissassembled to adjust it?
It depends on what AC system is in your car ,, some had the Compressor "swing away " (like the usual)......some had a lock nut...
Popularity: 36 • Tools: Recategorize
What type of power steering fluid does a 86 volvo 240 wagon use?
Most power steering units use the generic power steering fluid available at most auto part stores. However, some import makes are...
Popularity: 36 • Tools: Recategorize
How do you remove the driver door panel your door handle is stuck up and won't release?
(1) Wind down the window glass. (2) Bend one piece of stiff steel wire into the form of a small hook like the letter L with the...
Popularity: 36 • Tools: Recategorize
Why would the sparkplugs on a 1978 Volvo 245DL come loose while the engine is running?
Because they weren't tightened at installation properly. Because the threads in the head are stripped.
Popularity: 35 • Tools: Recategorize
The power windows do not work on your 1985 volvo the 16a fuse is good is there another power source?
Make sure you have the power connected to the switch, by taking a flat head screw driver and pop the whole plated that hold the...
Popularity: 34 • Tools: Recategorize
Why would not a clutch respond when it is let out 1983 Volvo 240?
Could be that someone stole your drive shaft or it fell out OR the linkage or cable release system is bound up or adjusted so...
Popularity: 34 • Tools: Recategorize
Where is the starter located on a 1986 240dl?
Follow the positive battery cable and it will lead to it.
Popularity: 33 • Tools: Recategorize
How do you remove and replace the tail light on a 1990 Volvo 240DL wagon?
If you can change flashlight batteries you can do this one. Open the tail hatch, and watch your head, since any 240 DL tailgate...
Popularity: 33 • Tools: Recategorize
How to start a 1984 240 series that has been sitting for 6 months?
I have a 1987 240 DL that sat for maybe a year or more. This is what I did and it started the first Crank; didn't even pump the...
Popularity: 33 • Tools: Recategorize
Your 240 DL only overheats when you drive up hill NO other times any ideas why?
The engine is working harder going uphill and thus creating more heat. Sounds like your cooling system is borderline. Drain and...
Popularity: 32 • Tools: Recategorize
Does the 1990 Volvo DL have a carburetor or is it fuel injected?
It has Bosch fuel injection. Answer All Volvos from 1968-2005 are fuel injected.
Popularity: 30 • Tools: Recategorize
Why does your Volvo 240 stall when you start it and put it into gear and only operate correctly if you give it gas for awhile with possiblility of an oxygen sensor problem and a check engine light?
Could be a dirty Throttle Box. This should be cleaned as part of a general tune-up.
Popularity: 30 • Tools: Recategorize
How do you replace the oxygen 02 sensor in a 1991 Volvo 240?
the 02 senser is on the manifold by the firewall on the passenger side under the hood [ behind and undr the spark plugs]
Popularity: 30 • Tools: Recategorize
Can you swap solid rotors for vented rotors on an 86 Volvo 240 DL?
NO!!!.....not unless you changed for old style calipers too.....why would you want to do it?....you would be seriously reducing...
Popularity: 30 • Tools: Recategorize
Where is the fuel relay for a 240 1989 right hand drive estate It's not under the dash or glove box?
Mine is behind the glove box: take out the glove box lining to reach it. The relay casing is green. That's in a 1989 UK spec...
Popularity: 29 • Tools: Recategorize
Where are the fuel filter or Filters fuel pump or pumps located on a 1989 Volvo 245 DL Wagon?
Fuel pump is in the fuel tank, the filter, if fitted, is in-line, usually a grey cylinder in the engine compartment.
Popularity: 28 • Tools: Recategorize
How do you stop the buzzing noise that occurs when using the turn signals on a 240 DL?
I am guessing that you have a bad turn signal relay. Locate it by sound and replace it.
Popularity: 28 • Tools: Recategorize
Volvo 240gle 1986 - 16a fuse on indicator circuit blows but that circuit is not the problem What else does that fuse serve - seat heater switches and what else Hazzards are OK always Cheers?
Tailgate wiring Fuse 11 supplies three things: Overdrive relay, seat heaters, and rear window defogger. Common problem on a...
Popularity: 28 • Tools: Recategorize
How do you remove and replace the rear automatic transmission seal and bearings on a 1988 Volvo 240 DL SW?
IPD used to sell a tool that would pull the bushing out without you having to remove that rear cone of the trans case....
Popularity: 27 • Tools: Recategorize
Your rear lights and dash lites stopped working - the rear directionals and reverse lights still work -- any ideas?
they're on different fuses....but i also suspect that it could be 2 different fuses are blown....check the ground connections to...
Popularity: 26 • Tools: Recategorize
How can you tell which wires to connect where for a 1987 Volvo 245 instrument panel if you failed to mark them when removing it?
they only go on one way kid proof the white and red wire is fot a tach if it has one if not just let it hang there 3 pin conector...
Popularity: 26 • Tools: Recategorize
How do you replace refrigerant in a 1989 volvo 240?
89 Volvo is R12(Freon).You need to go to a qualified tech to have it checked.A good idea is to have it converted to R134(have to...
Popularity: 25 • Tools: Recategorize
What is the necessary fuel pressure for a 1986 volvo 240?
it should be about 70 psi....and should remain like that for as long as possible after turning off engine - days even if all is OK
Popularity: 25 • Tools: Recategorize
Why do the window fuse keeps blowing on a 1990 Volvo DL?
First check to see that other items are not on the same curcuit as the window in question and that they are/are not working...
Popularity: 25 • Tools: Recategorize
Where can you get a diagram on how the wiring for a 91 volvo 240 front turning signal should be hooked up?
240 turn signal wiring I use WWW.alldata.com. There is a fee but the info is excellent. Also try looking for a green wire...
Popularity: 24 • Tools: Recategorize
How do you remove headrests from 1989 240dl and then replace it after new leather is installed?
The headrest has metal tubes that go down into the seat back, they go through plastic clips that have a button that you can...
Popularity: 24 • Tools: Recategorize
Where are the Fuel Pump and Fuel Pump Relay located in a 1989 Volvo 240 DL?
fuel pump is under the car on the drivers side under the rear seat. the fuel pump relay is under the foot kick pad on the...
Popularity: 24 • Tools: Recategorize
What is the fuel pump replacement procedure for a 1985 volvo 240 dl in tank pump. can you tell you how and do you have to remove the tank?
i suggest not replacing the pump, but installing an inline pump. you only need about 7 psi of pressure. so a $40 pump form an...
Popularity: 24 • Tools: Recategorize
When a 1988 Volvo 240 will crank but not turn over what could be the problem other than the fuel pump?
FUEL PUMP RELAY. IF YOU SHORT THE FUSEBOX TERMINALS FOR PRE PUMP AND MAIN PUMP YOU WILL BE BYPASSING THE RELAY. IF IT THEN STARTS...
Popularity: 24 • Tools: Recategorize
Where is the overdrive relay located on a 1991 Volvo 740 wagon?
remove the ash tray ....then depress cover behind ii....remove.....press both sides of fuse panel holder and slide out...
Popularity: 23 • Tools: Recategorize
What are the tail light bulb sizes and positions for a 1990 Volvo 240 DL?
PARTIAL ANSWER LOOK IN THE CARS OWNERS MANUAL IT CONTAINS ALL GLOBE/BULB INFORMATION. BRAKES ARE 21 WATT USUALLY
Popularity: 23 • Tools: Recategorize
1984 volvo dl 244 will not go in overdrive?
Assuming you have the rather peculiar electronic overdrive box connected to a manual transmission, the first place I would look...
Popularity: 23 • Tools: Recategorize
Where is the fuel pump and filter located in a 1990 Volvo 240?
Where your fuel pump and filter are Fuel pump in the rear of the car.. from underneath... when the car is on a lift. the...
Popularity: 22 • Tools: Recategorize
How do you figure out what is wrong with the fuel system on a 1980 Volvo 242?
Check your fuses first.
Popularity: 21 • Tools: Recategorize
Can you replace the taillight lens of a 1990 Volvo 240 with one from a 1984 Volvo 240?
If they're identical, yes. Try it and find out.
Popularity: 20 • Tools: Recategorize
What should be checked my 88 Volvo 240 has problems with power windows flood lights and light out sesor all aren't working the fuses under dash have been checked window motor works flood light new?
Not too sure if this will help. I have a volvo 1995 S90 with a similar problem - power windows, indicators and dash lights all...
Popularity: 20 • Tools: Recategorize
How do you fix a Leaking Sunroof in 1990 Volvo 240?
You can do this one of two ways. First and the best thing to do is to get some new weather stripping for it or you can find out...
Popularity: 20 • Tools: Recategorize
Where can you get the original wiring details for a 85 Volvo 240?
The closest manual on the market, will be the Haynes Manual. You will find that they are not all that complete either. You might...
Popularity: 19 • Tools: Recategorize
How do you replace a power steering hose on a 1988 Volvo?
A 1988 Volvo 240 has three power steering hoses: pressure hose from pump to rack, return hose from rack to reservoir and intake...
Popularity: 19 • Tools: Recategorize
How do you open the hood on your 1989 volvo 240dl?
left side under dash white handle pull out, the hood release is under hood in the middle.
Popularity: 19 • Tools: Recategorize
How do you replace a front left bumper on a 1990 volvo 240?
Popularity: 17 • Tools: Recategorize • Needs Answer
Why is the fuse blowing on your 1989 Volvo 245 overdrive circuit?
Probably because of the missing insulation from the wire leading from the solonoid on the transmission, causing the bare wire to...
Popularity: 17 • Tools: Recategorize
1990 240 volvo two 8 amp fuses for the left and right parking lights liscense plate lights and instrument cluster lights blow as soon as the parking lights are turned on the head lights work fine?
The most common cause for this is a fault in the cars tow bar wiring. If you dont have a tow bar the next best thing to check is...
Popularity: 17 • Tools: Recategorize
Your volvo 240 starts and idles good it will operate in reverse but every time you go to drive the engine stalls please help you get your volvo on the road again?
I worked for an Independent Volvo, and I got to see just this problem, sometimes the car would go, and sometimes it would stall....
Popularity: 16 • Tools: Recategorize
What is the gas mileage of a 1990 volvo 240?
Should get about 27 MPG highway, 21 city Manual Transmission 24 MPG highway, 21 City Automatic Transmission. -- my 1991 240...
Popularity: 15 • Tools: Recategorize
Is synthetic 5W30 the best engine oil to use for your Volvo 240DL?
Best is what the manufacturer recommends.
Popularity: 15 • Tools: Recategorize
How do you replace thermostat in 1986 Volvo 240?
Should be located in a removable housing at the engine end of the upper radiator hose Drain about 1 Gallon of coolant from the...
Popularity: 15 • Tools: Recategorize
Disconnected parking light turn signal light connections at feed throughs next to head lamps checked brake light bulbs 8 amp fuses instrument panel parking lights still blow parking lights trumed on?
Year,make, model does help... Probably a dead short. Unless its been pinched or modified (eg: trailer hitch added) most problems...
Popularity: 15 • Tools: Recategorize
How do you troubleshoot bad instrument cluster lights in a 1993 Volvo 240 with good bulbs and all other dimmed dash bulbs work fine?
Typically the problem lies with the rheostat, the knob you turn to make the dash lights brighter or dimmer. When you turn the...
Popularity: 14 • Tools: Recategorize
Where is the temperature sending unit located on Volvo 240DL?
on left rear side of engine block
Popularity: 14 • Tools: Recategorize
How do you remove the rear pads from a Girling caliper when no cotter pins visible?
BRAKE CALIPER PINS You have to drive the pins out useing a hammer and punch. The newer pins have a spring collar on them to...
Popularity: 14 • Tools: Recategorize
Where would the windshield wiper relay be located on a 1986 Volvo 245 DL?
On my 88 240 the wiper relay is located to the left of the clutch pedal, behind the insulation and a small metal plate - just...
Popularity: 14 • Tools: Recategorize
Where can you find a hand parking brake cover replacement part for a 240 DL Wagon?
That's a dealer item. It's available from Volvo World.
Popularity: 13 • Tools: Recategorize
How do you change the alternator on a 1988 Volvo 240?
Don't take this in place of a real technician, but here are a few things I've learned after recently replacing the alternator on...
Popularity: 13 • Tools: Recategorize
How do you fix a disgusting smell coming from the rear defogger of a 1989 volvo?
I hope to not let you down, but if its cold where you live you might have had a mouse crawl into your vehicle and die. It will be...
Popularity: 13 • Tools: Recategorize
Why won't the heated seats work if the fuse isn't blown on a 1987 Volvo 240 DL?
Large bag of ice Each heater is controlled by two switches in series: the manual switch on the e-brake console and the...
Popularity: 13 • Tools: Recategorize
How do you get to the starter of a 84 Volvo 240 and then start the process of replacing said starter?
Starter is located on the right, driver side of the car as you look into the engine compartment. Look down under the manifold and...
Popularity: 13 • Tools: Recategorize
Volvo 240 check engine codes?
Diagnostic Codes Volvo 89-93 models 1-1-1 No faults. 1-1-2 ECU. 1-1-3 Fuel injectors. 1-1-3 Heated Oxygen...
Popularity: 13 • Tools: Recategorize
1990 240 DL - Brakes lights are out - no owners manual - Fuse box open which fuse do you check for this?
Check all the fuses and replace all of the blown fuses. If you still have no brake lights check your brake light switch. The...
Popularity: 12 • Tools: Recategorize
How do you repair a passenger rear door lock?
Everyone should have a manual, and the library should have a professional shop manual available for copies in the reference...
Popularity: 12 • Tools: Recategorize
Volvo 240 DL wagon 1992 where is the electric window relay located refrenced Haynes manual but I can't find the relay behind the consul found other relays there however?
volvo window relay The relay is on the far right side, high up and behind the center console which houses the heater controls,...
Popularity: 12 • Tools: Recategorize
Where do you pour the power steering fluid in a 1985 Volvo 240 wagon?
Open the hood, look to your right (driver's side ). On a bracket bolted to the strut tower just above the battery there is a...
Popularity: 11 • Tools: Recategorize
What would make a Volvo 240 DL 1986 temperature gauge read hot even without the engine running?
Check the temperature sensor. You should be able to find a resistance value in your manual. If it is within specs, check to make...
Popularity: 11 • Tools: Recategorize
Fuel pump runs continuously even when you turn the car off you have to disconnect the negative battery cable in order for the battery not to die?
It's probably a stuck relay.
Popularity: 11 • Tools: Recategorize
Which spark plug wire socket on the spark plug distributor cap should the spark plug wire coming from cylinder number 1 be plugged into for a 1989 Volvo 240 DL?
Look at Volvo "Green Book" link included The plug wire socket closest to #1 cylinder. The second wire goes to its right, to...
Popularity: 11 • Tools: Recategorize
Is it a fuse issue if the headlights on your Volvo 240 GL aren't turning on but the brights work?
No you have a bad dimmer swith or the relay is stuck!
Popularity: 11 • Tools: Recategorize
Can you replace the tail light lens of a 1984 Volvo 240 DL sedan with the lens from a 1985 Volvo 240?
well compare them after you take them out becaue sometimes they have different connections and if they do then you have to switch...
Popularity: 11 • Tools: Recategorize
