answersLogoWhite

0


Best Answer

-You can buy an AC compressor bypass pulley on eB*y, that will hold your belt in place. I found it for $40.

You could go to the auto parts store and ask them for a belt on a car without a/c. It will be a shorter belt, and you will be able to operate your car indefinitely until you are able to repair/replace your compressor.

Good advice on the shorter belt, but there could be another way. If the compresser is locked up, but the electric clutch will still spin free, then simply never turning it on would work to a point. You can then never use your defrost however, because many cars cycle the AC compressor on when using defrost. You may be able to disable it electrically, remove the one wire running to the clutch, or easier yet, just pull the fuse for AC.

If the clutch is 'stuck on' as well as the compressor being locked up, this will not help. If the non-AC belt does not fit, you still may be able to get the right one, by running a piece of string or twine around every pulley, marking it then asking for a belt of that length. This measurement may be a little short because the string will be down against the pulleys, where the V-belts ride a little higher (the V gripping the sides is what turns it, not the bottom of the belt running on the pulley. Belts will stretch, but perhaps get one an inch or two longer than the string measurement.

If there is a bypass pulley you'd have to go to a dealer to get it. You can remove ac compressor and get a short belt bypass it that way. Same belt routing minus the ac. I just did my 2004 Ford Taurus used a 8206k belt. was a lil hard to get on or maybe I'm a wimp.

- 1998

817K6 from Autozone.

Assuming you mean install the belt without wrapping it around the compressor pulley then no. Unless you redneck it up and figure out a way to buy a smaller belt that will somehow wind it around everything else without the belt rubbing against anything. It is possible but not readily feasible.

The serp belt is made for specific engines and in a specific size. To not go around the AC pulley will require a shorter serp belt, which most likely is not available for your particular engine.

O'Reilly's Autoparts, MasterPro Belt # K060815 will allow bypass of A/C. Clearance is slight, but it works.

just did the smaller belt install today,you will need a 79inch belt for a 97 Jeep wrangler 4.0 with no air conditioming. real close to the seized pulley but very doable.auto zone has them....

I tried this on a 2001 Taurus and had no luck. Even with a belt that "fits"

the application when not wrapping around the AC compressor, I was unable to get the belt tensioner to loosen and tighten the belt in the normal manner so the effort was fruitless. You would have to remove and replace components to keep the belt tight enough because the tensioner won't give you the expected tension.

User Avatar

Wiki User

8y ago
This answer is:
User Avatar
More answers
User Avatar

Wiki User

12y ago

as in disabling it? remove the plug on the compressor on the engine and the clutch will not activate so it will not produce the cold air. When you want it back simply plug the plug back in.

Bypass probably means to route the belt without attaching it to the A/C compressor. I have the same problem, as the compressor is frozen, rendering the car unusable unless I can skip the compressor in the belt assembly.

This answer is:
User Avatar

Add your answer:

Earn +20 pts
Q: How do you bypass the air conditioner on a Ford Taurus Mercury Sable?
Write your answer...
Submit
Still have questions?
magnify glass
imp
Related questions

Is ford mercury making a sable model 2011?

No 2011 Mercury Sable model , but there is a 2011 Ford Taurus


Will the radiator on a 1995 Ford Taurus work for a 1995 mercury sable?

99% sure the Taurus radiator will be a perfect match to the Sable's.


Does a Ford Taurus and mercury sable have the same headlight lens?

No they do not


Can a Ford Taurus 1992 windshield fit in to a mercury sable 1996?

No, a Generation 2 (1992-1995) Taurus/Sable Windshield will NOT fit a Generation 3 (1996-1999) Ford Taurus/Sable.


Why would the air conditioner work fine but the heater not work in a 1996 1999 Ford Taurus Mercury Sable?

the air conditioner and heater are two separate things.(not connected) ;) it may have a fuse. or the it could just be bad.


How do tell whether your Mercury Sable or Ford Taurus is dual overhead cam or not?

The Mercury Sable and the Ford Taurus will have DOC in printed on the engine if they are dual overhead cam engines. The symbol should be on the top of the engine.


Will a windshield out of a 1999 Taurus fit in a 1998 mercury sable?

Yes, it is identical.


Does a alternator for a 1997 Ford Taurus work on a 1996 mercury sable?

Yes, it does.


Will the struts on a 1995 Mercury Sable fit a 1995 Ford Taurus?

Yes.


How many fuel pumps does a Ford Taurus - Mercury Sable have?

Just one handles the job. See "Related Questions" below for more about Taurus/Sable fuel pumps


Will a 215-75-15 fit a Mercury Sable?

Yes, I have them on my Taurus, identical body.


Will the fuel injectors from a 02 Ford Taurus fit a mercury sable?

Yes, they will fit.