2001 chevy cavalier 2.2L VIN-4 If chain broke or jumped: Remove right front tire and fender skirt. Remove serpentine belt and belt tensioner. Remove crank pulley and pull off pulley mount from crank. Remove the 10 mm bolts around timing chain cover remove two bottom studs on cover that pass threw oil pan use the two nuts on them as jam nuts on the studs. Studs must be removed. Carefully pry off cover. Remove cam shaft pulley remove chain, reinstall pulley(without chain) and turn cam shaft until cam shaft mark points to center of tensioner bracket. (I removed valve cover to make sure the two push rods for #1 cyl.were relaxed (They turned with two fingers). Turn crank place #1 cyl. t.d.c with crank. timing mark pointing @ center of the chain tensioner bracket.The mark is on the crank pulley a small circle on the gear, the keyway for the gear will be at the 12 o'clock posisition. Remove cam pulley again place new chain over crank gear while sliding cam pulley back on. Tighten cam pulley insure both gear marks still are aligned with bracket center and each other .Connect battery Test run for 5 sec. with covers off.Disconnect battery when engine starts and sounds normal. Now put everything back together.Go to http://www.jasperengines.com/pdf/GM2.2TimingTB.pdf to see timing marks and alignment.
Timing chain
The 2.2 and 2.4 litre four cylinder engines in a 2001 Chevrolet Cavalier have a timing CHAIN
It must have a TIMING CHAIN because Gates ( they make timing belts etc . ) does not list a timing belt for the 2001 Chev Cavalier 2.2 L
How do you replace timing chain & water pump on a2001 Chevrolet cavalier
How much does it cost for labor to change a timing chain in a 2001 Alltima ?
You don't. It has a Timing Chain
The 2.2 and the 2.4 both have timing chains
There is no belt to change; it uses an internal timing chain.
Always replace the timing chain, sprockets and tensioner rails whenever you remove the head.
the 2001 does not have a timing belt,instead a timing chain,which does not required replacement as often as belt
It does not have a timing belt, it has a timing chain that requires no maintenance.
The timing chain does not have a recommended change interval and should last for the life of the engine.The timing chain does not have a recommended change interval and should last for the life of the engine.