Raise the vehicle
Detach the wheel arch trim panal on the passenger's side
Remove six bolts
Remove the trim panel
The high service port is located in the engine compartment, drivers side radiator support
you can go to focushacks.com to see the step by step instructions (some of which I have included below) Once your on the site select maintenance below other hacks on the left hand side, the select air-conditioner refill and service.
Hopes this helps. I was able to refill mine using this information.
Larissa
2) With a Torx T30 driver, un-fasten the front part of the wheel well liner on the passenger side of the car.
3) With a Philips head screwdriver, un-fasten the 2 body snaps holding the wheel well liner. Then let the wheel well liner fall out of the way and rest on the tire.
4) Locate the Low-pressure A/C recharge port, which is on top of the receiver dryer (metal canister).
5) Attach the hose to the service port and examine the pressure. I've been told that while the car is off, a rule of thumb is that the pressure should be about the same as the ambient temperature in Fahrenheit. If it's 80 degrees outside, the pressure at this service port should be somewhere around 80 PSI.
6) Start the car and run the A/C on high with recirculation as shown below. This will make sure that the A/C pump is running as hard as possible. If the A/C compressor isn't running (you can usually hear it), the pressure may read high. If the A/C compressor never starts, or if it's short-cycling, the readings could be off.
on the 2001 Focus we found the low pressure port in the passenger front wheel well, hopefully this is consistent with the 2002 model good luck
how do you align the crank pulley in reference to the cam pulley on a 2002 escort?
I need a diagram of the headlight adjusting screws.
In a 2002 Escort ZX, the fuel pump has a check valve built into it. If the fuel pressure is dropping, then it is a bad pump. You would need to replace the entire pump. It could also be low compression.
There should be a placard with a diagram of the routing of the belt, located under the hood.
To recharge the AC on the 2002 Ford Escort ZX2 you need to use the low pressure fill port. It is located on the larger of the two hoses coming off the compressor.
Try near accumulator/drier on the firewall passenger side
how do you remove the water pump in a 2002 ford escort
On a 2002 Ford Escort zx2 the fuel pump relay is located under the hood, in the fuse box. If there is no diagram under the lid, the owners manual should have a picture. However if you do not have one of those it will be the tall, almost perfect square that says FORD on it.
No
yes
If they are of the same model.